12. 直立円筒凍結乾燥における凍層形成と未凍溶液部の濃縮現象(平成4年度第38回凍結及び乾燥研究会研究報告)

DOI

書誌事項

タイトル別名
  • 12. Solute Concentration in the Non-Frozen Liquid during the Frozen Layer Formation in Vertical Tube Freeze-Dryer : Continued Report on a Closed System for Freeze-Drying of Liquid(Papers presented at the 38th Annual Meeting)

抄録

In a process of freeze-drying of liquid material by the use of vertical tubes, it is important that the solute concentration upon thawing of the frozen layer C_f should be equal to that of the non-frozen liquid removed away from the tubes C_I when desired amount of the frozen layer is formed. Phenomena taking place in the frozen layer formation with several aqueous solutions, mostly sucrose and dextrin, were analysed in this study. The influences of initial solute concentration C_o, freezing rate (cooling brine temperature T_h and percentage of the frozen layer to the amount of liquid poured into a tube β on C_f and C_1 have been studied experimentally. In each case for C_o=10, 20, and 30 wt % of sucrose, the difference between C_f and C_1 was observed only under slow freezing conditions, i.e. growth velocities of a couple of centimeters per hour or less (T_h≧-20℃). While for dextrin solutions, any concentration changes did not occur. Availability of "Multi-Stage Frozen Layer Formation" was confirmed in this study.

収録刊行物

詳細情報 詳細情報について

  • CRID
    1390001205086806912
  • NII論文ID
    110007368514
  • DOI
    10.20585/touketsukansokaishi.38.0_83
  • ISSN
    24329916
    02888297
  • 本文言語コード
    ja
  • データソース種別
    • JaLC
    • CiNii Articles
  • 抄録ライセンスフラグ
    使用不可

問題の指摘

ページトップへ