銅製錬転炉における造銅期の反応解析

DOI Web Site 被引用文献2件 参考文献13件
  • 黒川 晴正
    住友金属鉱山(株)金属事業本部　銅・貴金属事業部
  • 家守 伸正
    住友金属鉱山(株)金属事業本部　ニッケル事業部

書誌事項

タイトル別名
  • Reaction Mechanism in Copper-making Stage of PS Copper Converter.
  • ドウ セイレン テンロ ニ オケル ゾウドウキ ノ ハンノウ カイセキ

この論文をさがす

抄録

Oxygen probes were applied to a PS converter in copper-making operation, and the oxygen pressures of white metal and blister copper in the converter were measured through the converter's mouth and through a tuyere, respectively. Based on the obtained results, the following reaction mechanism has been deduced.<BR>(1) The copper-making stage of a PS converter may be classified into three stages, i.e. the early substage where the tuyeres are completely in white metal, the intermediate substage where both phases of white metal and blister copper coexist in the converter and the tuyeres are in the blister copper, and the final substage where the white metal has disappeared from the converter.<BR>(2) In the early stage, direct oxidation of white metal by oxygen gas contained in the reaction air progresses in the vicinity of the tuyeres.<BR>Cu2S(l) + O2(g) = 2Cu(l) + SO2(g) …………… (1)<BR>(3) In the intermediate substage, the following three reactions proceed near the tuyeres, at the interface of blister copper and white metal phases, and in the bulk of the blister copper, respectively.<BR>O2(g) = 2O(l) …………… (2)<BR>Cu2S(l) = 2Cu(l) + S(l) …………… (3)<BR>S(l) + 2O(l) = SO2(g) …………… (4)<BR>Here the most important factor is that reaction(4) progresses under the condition of PSO<sub>2</sub>=1atm. It is not dependent on how high the SO2 pressure of the waste gas from the converter is. Because the condense phases, i.e. the white metal and blister copper phases, are not in equilibrium with the gas phase.<BR>(4) In the final substage, reactions(2) and (4) only proceed because the white metal is no longer in the converter. Some of the blister copper can be excessively oxidized to the extent that Cu2O(s) is formed according to equation(5). However the final degree of oxidation of the whole blister copper does not reach this level.<BR>2Cu(l) + 1 / 2 O2(g) = Cu2O(s) …………… (5)

収録刊行物

  • 資源と素材

    資源と素材 119 (2), 55-60, 2003

    一般社団法人 資源・素材学会

被引用文献 (2)*注記

もっと見る

参考文献 (13)*注記

もっと見る

キーワード

詳細情報 詳細情報について

問題の指摘

ページトップへ