伸長結晶とゴム物性

DOI Web Site Web Site 参考文献16件

書誌事項

タイトル別名
  • Strain-Induced Crystallization and Mechanical Properties of Rubber.
  • 特論講座 伸長結晶とゴム物性(第4回)結晶と微結晶の構造
  • トクロン コウザ シンチョウ ケッショウ ト ゴム ブッセイ(ダイ4カイ)ケッショウ ト ビケッショウ ノ コウゾウ
  • 第4回　結晶と微結晶の構造
  • 4. Crystal and Crystallites Structure

この論文をさがす

抄録

<p>1. Unit cells of strain-induced crystals of NR, vulcanized NR, IR, vulcanized IR are the same because cis-1, 4-polyisoprene makes crystal units with exclusion of entanglements and network points. Unit cell of cis-1, 4-polyisoprene is composed of four chains with P212121 symmetry.</p><p>2. Crystallites of NR, vulcanized NR, IR and vulcanized IR are cubic figure with the size of several nm being composed of around 100 chains. The sizes depend on temperature but do not increase with strain. The crystalline fraction increases with strain due to increase of the number of crystallites. Crystallites could be considered as a giant crosslink point, but many crosslink points are bound together at the upper and lower outside of crystallites. Therefore, crystallites do not increase necessarily the number of amorphous molecules which contribute to the elasticity of rubber.</p><p>3. WAXD patterns are affected by the size of crystallites, the orientation of crystallites and the completeness of crystal. We developed a simulation program to analyze the size, orientation and completeness of crystallites. The X-ray scattering peaks of NR and vulcanized NR are crescent figure, on the other hand the ones of IR and vulcanized IR are round. The differences are caused by the degree of orientation of crystallites, the crystallites of NR and vulcanized NR do not orient more than the ones of IR and vulcanized IR. The crystallites of NR and vulcanized NR are less degree of completeness of crystal than IR and vulcanized IR, although the stereo-regularity of NR is higher than the one of IR. Pseudo networks of NR and vulcanized NR may suppress a crystallizing process of strain-induced crystallization.</p><p>4. Higher order structure of crystallites such as the lamella structure is not observed well although NR show slight two points SAXS pattern only at 0 °C at strain 6.0. During stress relaxation after deformation, density fluctuation is observed due to orientation. It is not considered to be caused by strain-induced crystallization.</p>

収録刊行物

  • 日本ゴム協会誌

    日本ゴム協会誌 91 (4), 129-134, 2018

    一般社団法人 日本ゴム協会

参考文献 (16)*注記

もっと見る

キーワード

詳細情報 詳細情報について

問題の指摘

ページトップへ